Back to the list

REAGENT TANK

  • 1
  • 2
  • 3
  • 4
  • 5

Please ensure that you comply with the legislation of your country.

It is important to remember that failure to respect regulations in force could lead to legal action being taken against the vehicle owner.

Operating principle

The reagent is intended for Diesel engines fitted with the SCR (selective catalytic reduction) system.

Using the reagent reduces the quantity of nitrogen oxides in exhaust gases.

Reagent consumption in real time depends on vehicle usage conditions, the equipment fitted, and driving style.

Reagent quality

Use only reagents which conform to standard ISO 22241 and in accordance with the mark on the tank filler cap.

Topping up

Useful capacity of fuel tank: approximately 21 litres or 28 litres (depending on the vehicle).

Ignition off, open the front passenger door to open the cover 2. Unscrew the cap 1.

Note: ammonium hydroxide vapour may escape from the cap opening when the tank temperature is high.

To fill up with reagent, the engine must be stopped (not just on standby in the case of vehicles with the Stop and Start function). You must switch off the ignition STOPPING, STARTING THE ENGINE, FUNCTION STOP AND START.

If the “xxxKM failure Top up AdBlue” message appears, fill the reagent tank and refer to the filling instructions.

Risk of immobilisation of the vehicle.

Filler cap: this is specific.

If you have to replace it, make sure it is identical to the original cap. Contact an approved Dealer. Do not wash the filler area with a high pressure washer.

Precautions for use

The tank can be filled at the pump. In other cases, it is essential to read the information shown on the reagent container (e.g. the can or bottle).

When filling, handle the reagent carefully. They can damage clothes, shoes, bodywork components etc.

If the reagent overflows, or contaminates any paintwork, clean the affected area quickly with plenty of cold water and a soft cloth.

Note: if the reagent crystallises, use a soft sponge.

The reagent must not come into contact with eyes or skin. If it does, wash the affected area with plenty of cold water. If necessary, consult a doctor.

In extreme cold weather conditions

In frosty conditions, fill the reagent tank as soon as the warning light and the “TOP UP AdBlue before 1500 km” message, or, depending on the vehicle, the “TOP UP AdBlue before 1200 km” message is displayed on the instrument panel.

Special cases

The reagent fluid freezes below about -10°C.

In these conditions, do not attempt filling when the fluid is frozen. In the event of needing to top up or fill the tank with reagent ( on), park the vehicle in a hotter location if possible so that the reagent becomes liquid again. Otherwise, have a qualified professional top up or fill up with reagent fluid.

After filling the reagent tank, check that the cap and cover are closed, start the engine and WAIT 10 seconds with the vehicle stationary, engine running, before setting off again.

If this operation is not carried out, the filling of the tank will not be taken into account automatically until after several dozens of minutes of driving.

The message “--- TOP UP AdBlue” and/or the warning lights will continue to appear until the filling has been registered by the system.

No work whatsoever is permitted on any part of the system. To prevent damage, only qualified personnel from our network may work on the system.

Alert with message on the instrument panel on display 3

Front-wheel drive and van versions

Warning lights and the messages on the instrument panel 3are displayed according to the estimated range of the remaining reagent.

Depending on how the vehicle is driven, they may be displayed before the reagent gauge on the instrument panel is at minimum DISPLAYS AND INDICATORS.

Maintenance/Range

The information displayed on the instrument panel may be accompanied by a beep.

Indicator lights

Messages

What to do?

-

AdBlue Level Correct (depending on the vehicle)

-

-

“Top Up AdBlue before 2400 km”

If the message is displayed when the ignition is switched on, you have less than 1,491 miles (2,400 km) range remaining.

Refill, or have an approved dealer refill the reagent in the tank.

comes on.

“TOP UP AdBlue before 1500 km” or, depending on the vehicle, “TOP UP AdBlue before 1200 km”

If the message is displayed when the ignition is switched on, you have between 932 miles (1,500 km) and 621 miles (1,000 km) range left or, depending on the vehicle, between 745 miles (1,200 km) and 497 miles (800 km) range left.

Refill, or have an approved dealer refill the reagent in the tank.

Maintenance/Range

The information displayed on the instrument panel may be accompanied by a beep.

Indicator lights

Messages

What to do?

comes on.

“xxxKM failure Top up AdBlue”

The message is displayed when the ignition is switched on and is repeated:

- approximately every 62 miles (100 km), you have between 621 miles (1,000 km) and 124 miles (200 km) range left or, depending on the vehicle, between 497 miles (800 km) and 124 miles (200 km) range left;

- Approximately every 31 miles (50 km), you have less than 124 miles (200 km) range.

In any event, you or an Approved Dealer should fill the reagent tank as soon as possible.

flashes or comes on, depending on the vehicle.

“0KM failure Top up AdBlue”

The engine will not start.

To restart, you must fill the reagent tank yourself.

System faults

When the indicator lights described light up, this may be accompanied by a beep.

Indicator lights

Message

Readings

and © come on.

“Check Anti- Pollution System”

“AdBlue quality to check”

“AdBlue injection to check”

Indicates a fault in the system. Contact your approved dealer as soon as possible.

and © come on.

“xxxKM failure antipollution”

This indicates a system fault and that you have less than 621 miles (1,000 km) range left or, depending on the vehicle, less than 497 miles (800 km) range left before it is no longer possible to restart the vehicle.

These warnings are repeated:

- every 62 miles (100 km) until you have between approximately 621 miles (1,000 km) and 124 miles (200 km) range left or, depending on the vehicle, between 497 miles (800 km) and 124 miles (200 km) left before it is no longer possible to restart the vehicle;

- Every 31 miles (50 km) when there is less than 124 miles (200 km) left before the vehicle cannot be restarted.

Contact your approved dealer as soon as possible.

and © come on.

“0KM failure antipollution”

Indicates that after the ignition is switched off the vehicle will not restart. Call an approved Dealer.

Alert with no message on the instrument panel

Bus and rear-wheel drive versions

The warning light is displayed according to the reagent level indicated by the gauge 4 on the instrument panel.

Maintenance/Range

Gauge level

Warnings

What to do?

Range A

-

-

Range B

comes on.

You or an Approved Dealer should fill or top up the reagent tank.

Range C

flashes for a few seconds at the start of the warning and each time the ignition is switched on, then stays on.

Range D

flashes for a few seconds at the start of the warning and each time the ignition is switched on, then stays on. It is accompanied by beeps.

Loss of engine power.

You or an Approved Dealer should fill the reagent tank as soon as possible.

At E

Empty tank.

flashes accompanied by beeps.

In this case, at the next engine stop/start, the vehicle speed is limited to approximately 12 mph (20 km/h) until you fill the reagent tank or have it done by an Approved Dealer.

System faults

When the indicator lights described light up, this may be accompanied by a beep.

Indicator lights

Message

Readings

and © come on.

“Check Anti- Pollution System”

Indicates a fault in the system. Contact your approved Dealer as soon as possible.

and © flash when the engine is started then stay lit.

-

Indicates a system fault with a loss of engine power. Contact your approved dealer as soon as possible.

flashes and © comes on.

-

Indicates a fault in the system. In this case, at the next engine stop/start, the vehicle speed is limited to approximately 12 mph (20 km/h). Contact your approved dealer as soon as possible.